biomass pellet thermic fluid boiler
Industrial boilers
Product thermal capacity: 4-35 t/h
Working pressure: 1.0-2.5 MPA
Outlet temperature: 184-350 ℃
Available fuel: natural gas, coke oven gas, bio-gas，liquid propane gas, diesel, heavy oil, light oil, crude oil
Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
- Product introduction
- Technical advantages
Introduction
biomass pellet thermic fluid boiler have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.
biomass pellet thermic fluid boiler.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).
Digitized manufacture
- The laying-off of steel tube adopts CNC 3D laser cutting machine.
- The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
- The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
- Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
- Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
- The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
- Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
- Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
- Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
- The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
- Conical coil effectively protects the furnace wall at the end of heater and burner on the top. 、
bagasse thermic fluid heater Hospital | Industri
Steam boiler, electric heating steam boilers, hot water … Sitong boiler manufacture and export variety industrial boilers, various fuels can be fired, coal biomass oil gas steam and hot water boilers, thermal oil boiler and electric steam ...
Coal or Biomass Thermic Fluid Heater-yuanda-steamboiler.c
The Introduction of Coal/Biomass Thermic Fluid Heater: Coal/Biomass Fired Thermal Oil Heater (YLW series) are square coil horizontal structures. It is loaded with chain grate, equipped with drums and induced draft fans for mechanical ventilation, and equi
1200KW pellet oil furnace | Horizontal Boile
1200KW pellet oil furnace May 25 2019 News 1200kw biomass boiler industrial – flashpoints.com.au Oil Fired Heater 28th June Output range 420 to 1850 kW – bosch The oil/gas-fired Uni 3000 F floor-standing high efficiency boilers.
Industrial Coal / Biomass / Gas / Oil fired Thermic Flu
Sitong thermic fluid heater manufacturer. Coal biomass fired thermic fluid heater for sale, oil gas fired thermic fluid heater for for sale.
biomass pellet fired boiler - electricheatingboiler.c
Wood Pellet Boilers -Grant High Efficiency Biomass Boiler. ... coal biomass oil gas steam and hot water boilers, thermal oil boiler and electric steam boiler are innovative designed.Biomass & Wood Fuelled Heating | Energy Saving Trust2019-4-19 · Maintenan
Coal/Biomass Fired Thermic Fluid Heater - Horizontal oil fired boil
Sitong YLW series horizontal type thermal oil boiler is a safe and energy saving boiler with working characteristics of low pressure (1.0 MPa) and high temperature (350℃). The combustion Because of working in liquid state, the vertical type coal/biomass f
biomass pellets steam burner \/boiler \/ sto
The series boiler is vertical industrial water tube oil fired steam boiler. steam capacity is 0.1-2t/h. thermal efficiency is 92%. Biomass Fired Thermal Oil Boilers The 360,0000Kcal biomass fired thermal oil heater use for plywood plant in Indonesia. ther
Wood Chips fired Thermal Fluid Heater | Industri
Biomass Fired Thermic Fluid Heater – stong-boiler.com. YLW series biomass fired thermic fluid heater is an safe and energy saving boiler with working characteristics of low pressure (0.8 MPa) and high temperature (330℃). The combustion equipment is chain
ECOENERGY Wood Pellets & ECOPOWER Biomass Pellets - Bholana
ECOPOWER Biomass Pellets is eco-friendly fuel made from Pine Wood & Bio-mass materials, very efficient and specially made for industrial use to to replace currently used fuel such as Coal, Wood, Wood Chips, Kerosene, Diesel, LDO and LPG. For all large sca
biomass fired thermic fluid heat
Alibaba.com offers 115 biomass fired thermic fluid heater products. About 4% of these are industrial heater. A wide variety of biomass fired thermic fluid heater options are available to you, There are 35 biomass fired thermic fluid heater suppliers, main
Thermic Fluid Heater and Steam Boiler Manufactur
2018/08/03 · [www.firetechengineers.co.in/] Leading Thermic Fluid Heater and Steam Boiler Manufacturer and many other products. Share your details here to get free price ...
economical biomass fired thermal oil heater - Biomass Boil
Wood pellets are the most common type of pellet fuel and are generally made from compacted sawdust and related industrial wastes from …Thermax - Packaged | BoilersA part of Thermax heating business, this strategic business unit offers packaged boilers, th
Wood Pellet Hot Air Furnace | Wood Pellet Steam Generat
You are here: Home / Wood Pellet Hot Air Furnace Hot air furnace is widely used in textile bleach and dye industry, rubber coating heat setting, printing coating for iron oast room, drying of metal surface derusting, oil paint drying, paper manufacturing
12000KW pellet thermic fluid heater | Steam generator boil
Biomass Fired Thermic Fluid Heater – stong-boiler.com. YLW series biomass fired thermic fluid heater is an safe and energy saving boiler with working characteristics of low pressure (0.8 MPa) and high temperature (330). The combustion equipment is chain g
biomass pellet thermic fluid boiler | Zozen Boil
biomass pellet thermic fluid boiler Boiler Type ZOZEN boiler covers an area of 150 thousand square meters, with an annual production capacity of 2000 industrial boilers and 25000 tons of steam.Our products have been sold to more than 100 countries and reg
pellet thermal oil heater for Rice Mill - Chain Grate Ste
Steam boiler, electric heating steam boilers, hot water … 2018-10-24 · Sitong boiler manufacture and export variety industrial boilers, various fuels can be fired, coal biomass oil gas steam and hot water boilers, thermal oil boiler and electric steam boi
biomass thermal oil heating boil
biomass pellet thermal oil boiler – Wood Pellet Boiler Price • Biomass is produced in two formats: – As a fuel directly grown as an 'energy crop' eg wood; high yield – As a waste bi product eg Boilers and thermal groups for the heating ...
pellet biomass steam boiler - emahospitality.c
They range from 1.5 to 9 MW, with water-tube or fire-tube boilers (low or high pressure) for process or heating. View More; Cyclone WHE Biomass Pellet Power Generator | PelHeat. Most of the articles I write to promote the use of biomass pellets is their u
biomass boilers – Thermic Fluid Heater, Hot oil Boil
wood boilers, wood pellet boilers, wood chip boilers, by … 2019-2-17 · Tarm Biomass sells indoor wood gasification boilers. Indoor boilers can be located in detached buildings outside of the primary heated space, but they are not weatherized like outdoor
1200000kcal/h peanut shell thermic fluid heater | Sito
Biomass Fired Thermic Fluid Heater – stong-boiler.com. YLW series biomass fired thermic fluid heater is an safe and energy saving boiler with working characteristics of low pressure (0.8 MPa) and high temperature (330℃). The combustion equipment is chain