steam generator sterilizer

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

steam generator sterilizer have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


steam generator sterilizer.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
Steam Generators - Primus Sterilizer

Steam Generators - Primus Sterilizer

We offer steam generators to fit the needs of your sterilizer based on your product requirements. From Carbon Steel Boilers to Pure Steam-to-Steam Generators, PRIMUS can meet all your needs. Carbon Steel Steam Generator. Stainless Steel Steam Generator. C

OPERATOR MANUAL Century Medium Ste

OPERATOR MANUAL Century Medium Ste

The Amsco ® Century TM Medium Steam Sterilizer 26" x 37.5" (660 x 950 mm) is designed for sterilization of heat- and moisture-stabile materials used in healthcare facilities and is available in two medium size models: • • ...

Steam Generators for Sterilization - Electric Ste

Steam Generators for Sterilization - Electric Ste

Steam Generators for Sterilization Reimers Electra Steam is a manufacturer of carbon & stainless steel electric steam boilers for steam sterilization applications, such as, autoclave, medical waste, medical research, and ...

Steam Boiler Ton

Steam Boiler Ton

mitsubishi water tube boiler vu 60 – energy-saving boiler mitsubishi water tube boiler vu 60 – Steam Boilers 60 ton heavy oil boiler – Steam boiler Center. Water Tube Boiler 60 Ton, Water Tube Boiler 60 Ton Mitsubishi Sectional Drum ...

AMSCO™ 400 Small Steam Sterilizer - steris-healthcare.c

AMSCO™ 400 Small Steam Sterilizer - steris-healthcare.c

- Non-lubricated, steam activated door seal - Hinged front cabinet panel fully opens for convenient access to sterilizer piping and control - Predictive maintenance with remote monitoring - Steam generator units equipped with an automatic flush and drain

EASCO Series FST, ESP, SM4, SM5, PLW 3-Pass a

EASCO Series FST, ESP, SM4, SM5, PLW 3-Pass a

4.11 Cleaning a New Hot Water Boiler..... 24 SECTION 5: OPERATION INSTRUCTIONS..... 26 5.1 Boiler 5.2 Feed Water Connection..... 27 5.3 Firing 5.4 Pressure and Temperature 5.5 Water Level 5.6 Maintenance of Low Water ...

“STEAM HIGH TEMPERATURE STERILIZER

“STEAM HIGH TEMPERATURE STERILIZER

Since 1946, CISA is following new updated and developed technology for steam sterilizers. This technology is based on accumulated experience through the years, investments and innovative R&D office introducing continuous ...

Autoclaves - Hospital Sterilizer Equipment | STER

Autoclaves - Hospital Sterilizer Equipment | STER

Healthcare Steam Sterilizers. Steam sterilizers (also referred to as autoclaves) are an essential part of the decontamination and sterilization process performed by sterile processing departments (SPD) in healthcare facilities. STERIS offers the broadest

ROUTINE MAINTENANCE Amsco Century Series Sterilize

ROUTINE MAINTENANCE Amsco Century Series Sterilize

Before flushing generator, ensure generator drain valve is fully open to prevent generator heaters from turning on during flush phase. Sterilization of chloride-containing solutions (e.g., saline) can cause chamber corrosion and is not recommended by the

Design Technology for Supercritical Sliding Pressu

Design Technology for Supercritical Sliding Pressu

Mitsubishi Heavy Industries Technical Review Vol. 50 No. 3 (September 2013) 61 Figure 2 Load follow-up performance at overseas plant (as high as 5%/min) |3. Advantages of Mitsubishi vertical tube boilers Figure 3 and Table 16 show the advantages of vertic

AMSCO ELECTRIC STEAM GENERATORS - CES SERI

AMSCO ELECTRIC STEAM GENERATORS - CES SERI

3 ENGINEERING DATA Rating (kW) 30 40 60 75 100 120 150 180 Developed Boiler Horsepower 3.1 4.1 6.1 7.710.4 12.2 15.3 18.4 Generator Steam Output -- lbs/hr (kg/hr) 70 F (21 C) feedwater - 80 psig 89.3 119 178.5 223 297.5 ...

Steam Sterilizer - Machinfabrik - Ho

Steam Sterilizer - Machinfabrik - Ho

Features Vent filters with automatic sterilization in place and attachments for water-Intrusion-Test. Option of jacket cooling for liquid loads. Electrically heat steam generator for Laboratories & Research Intuitions. Attachments for ...

Steam Sterilizers And Generator | Manufacturer from Mumb

Steam Sterilizers And Generator | Manufacturer from Mumb

...which include Steam Sterilizer, Stainless Steel Steam Sterilizer, Automatic Steam Sterilizer and Providing you the best range of Pure Steam Generator and Steam Generator with effective & timely...

AMSCO™ CENTURY™ Small Steam Steriliz

AMSCO™ CENTURY™ Small Steam Steriliz

- Pressure gauges for jacket, chamber, steam generator (loading side), chamber (unloading side) - Water level gauge for steam generator - Safety temperature switch for door opening - Doors equipped with safety bumper for workers safety - Acoustic signal f

Soil Sterilization Using Steam-Flo Steam Generato

Soil Sterilization Using Steam-Flo Steam Generato

Soil Sterilization Using Steam-Flo Steam Generators Sioux Corporation has been designing and manufacturing steam generators and steam cleaning equipment since 1939 with the Steam-Flo ® steam generator being our longest running line of equipment. One of th

LSS 450 Laboratory Steam Sterilizer - lancer.c

LSS 450 Laboratory Steam Sterilizer - lancer.c

The Model LSS 450 Steam Sterilizer is designed for high-performance sterilization of labware, media and laboratory byproducts used in research, analytical, environmental and industrial laboratories. This steam sterilizer employs gravity downward displacem

Steam Generator Sterilizer, Steam Generator Sterilizer Supplie

Steam Generator Sterilizer, Steam Generator Sterilizer Supplie

steam generator sterilizer are produced with foreign advanced technology integrating with our own abundant technical personnel and prefect mold in accordance with the principle mentioned above...

Sterilizer Sterilizers Sterilization Autoclave Autoclav

Sterilizer Sterilizers Sterilization Autoclave Autoclav

Bioclave Sterilizer Steam Generator. Bioclave Sterilizer Autoclave Steam Generator. Be the first to review this product.

Steam Generators | Consolidated Sterilizer Syste

Steam Generators | Consolidated Sterilizer Syste

Steam Generators. When house steam is unavailable or inadequate, the Consolidated ProGEN™ electric steam generator serves as the steam source. Developed to fit directly below the sterilizer chamber within the chassis, the ProGEN™ is designed to deliver a

Steam Generators Sterilizers - Autoclaves & Instrumen

Steam Generators Sterilizers - Autoclaves & Instrumen

Steam Generators for Sterilization. Reimers Electra Steam is a manufacturer of carbon & stainless steel electric steam boilers for steam sterilization applications, such as, autoclave, medical waste, medical research, and dental instrument sterilizers.

steam generator to sterilizer - Industrial Oil Boile

steam generator to sterilizer - Industrial Oil Boile

Steam Generators for Sterilization. Reimers Electra Steam is a manufacturer of carbon & stainless steel electric steam boilers for steam sterilization applications, such as, autoclave, medical waste, medical research, and dental instrument sterilizers.