Product thermal capacity: 4-35 t/h
Working pressure: 1.0-2.5 MPA
Outlet temperature: 184-350 ℃
Available fuel: natural gas, coke oven gas, bio-gas，liquid propane gas, diesel, heavy oil, light oil, crude oil
Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
condenser boilers have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.
condenser boilers.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).
As a condensing boiler necessitates more parts, it will always cost more than a conventional boiler. In addition, condensing boilers using single heat exchanger designs will require better materials to handle the increased heat - using stainless steel in
Condensing boilers have additional heat exchange elements and are manufactured of the right materials to withstand corrosive condensates. The Eurogen Condensing Fire Tube Boiler depicted above is one example of a condensing boiler. The hot combustion gase
May 23, 2008 · The flue of a condenser boiler. Photograph: David Levene. Condensing boilers work by recovering waste heat that would normally be lost to the atmosphere through the flue of a conventional boiler.
Boiler Flue Condensers. There is a class of economizers that are designed to condense the flue gases and/or have the water in direct contact with flue gases.
heating oil boiler service electric combi boiler electric water boiler condensing boiler condensing boilers condenser boiler boiler servicing boiler service cost gas boiler service.
1/5/2011 · These boilers rarely operate at maximum efficiency anyway. Explained simply, the water returning from your radiators back to the boiler has to be below 55c for the condenser …
U.S. Boiler Company is a leading manufacturer of home heating equipment, water boilers, steam boilers, domestic hot water heaters, and radiators. Included in our extensive selection of heating products are high efficiency gas-fired residential boilers, in
Condensing Boilers prices vary from £500 to £1,700 depending on the brand or output. Condensing boilers prices vary dependent on your budget. You can, for example, buy a perfectly good condensing boiler from a top brand, such as; Baxi, Valliant, Potterton
The new worthy contender is the Autoclaved Aerated Concrete (AAC) Block. AAC Blocks are pre-fabricated (pre-cast) building blocks that beat the old rival hands down on every count. AAC Blocks are pre-fabricated (pre-cast) building blocks that beat the old
The steam condenser of a power plant boiler is a critical heat exchanger in the process. Poor performance due to restricted heat transfer can have a dramatic influence on unit efficiency. And ...
Energy efficiency in hospitals: condensing gas boilers Condensing gas boilers for heating and hot water in hospitals Running cost savings of 10 - 20% Paybacks under three years High efficiencies using conventional system design Easy to install and maintai