boiler horizontale

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

boiler horizontale have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


boiler horizontale.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
normal pressure 10t/h parts of boiler | Horizontal Boile

normal pressure 10t/h parts of boiler | Horizontal Boile

The best fuel for steam boiler is rice husk, which can save cost. stoker 10t/h heating boiler operators – Industrial Gas …0.1t/h normal pressure parts of boiler | Sitong wood …0.1t/h normal pressure parts of boiler. 13 Jun 0.1t/h normal pressure parts of

Greenstar 100mm Flue Horizontal Installation and Servici

Greenstar 100mm Flue Horizontal Installation and Servici

central heating boilers, combi boilers, gas boilers, oil boilers, gas central heating, heating engineers, boiler installation, boiler repair. We use cookies to create the most secure and effective website possible. By continuing to use our website you are

HORIZONTAL BOILER - Martin Baylis Engineeri

HORIZONTAL BOILER - Martin Baylis Engineeri

The boiler is supplied with sight glass, steam valve, pressure gauge and ceramic burner. Options include feed water heater, gas attenuator, combined by-pass/check valve, blow down valve, rechargeable gas tank and oil separator. Image showing the horizonta

boiler | Industrial Horizontal Steam Boil

boiler | Industrial Horizontal Steam Boil

2018-2-7 · Boiler – Wikipedia A boiler is a closed vessel in which water or other fluid is heated. The fluid does not necessarily boil. (In North America, the term "furnace" is ...

Low Pressure Steam System – L.E.S Boilers | Horizont

Low Pressure Steam System – L.E.S Boilers | Horizont

Boiler, Feedwater System, Water Softener, Blowdown Separator • Low pressure steam boiler, 83% efficient • Duplex boiler feed system • Twin alternating water softener • Blowdown separator with cooling package • Single point connection for utilities: Natura

Steam Power Generator Same As Boiler - emetreinta.

Steam Power Generator Same As Boiler - emetreinta.

A boiler or steam generator is a device used to create steam by applying heat energy to water.Although the definitions are somewhat flexible, it can be said that older steam generators were commonly termed boilers and worked at low to medium pressure (72,

van marcke horizontale boilers | SITONG BOIL

van marcke horizontale boilers | SITONG BOIL

Boiler-shop.be | Bestel uw boiler voordelig online. Bestel uw nieuwe boiler via onze webshop en bespaar tot 50% op de officiële prijs! Stockproducten voor 16u besteld, kunnen de volgende werkdag reeds geleverd worden. ... Category : Industrial Boiler van

boiler for pakistan - adeelectricidad.o

boiler for pakistan - adeelectricidad.o

horizontale elektrische boiler; Seven Hold Points. Seven hold points are set and each one is supervised by a responsible inspector. Any work that fails to pass the inspection cannot proceed until the inspector is able to verify its quality. 1,Incoming mat

Series VW Boiler – L.E.S Boilers | Horizontal Boile

Series VW Boiler – L.E.S Boilers | Horizontal Boile

Direct Hydronic Boilers. High Efficiency: Series VW boilers are positive pressure non-condensing appliances. They are equipped with forced-draft burners for reliable 83% efficient combustion. High-temperature fiberglass rope is used to gasket burner flan

Eldom horizontale elektrische boil

Eldom horizontale elektrische boil

7/2/2018 · Elektrische boilers van het merk Eldom voor horizontale bevestiging aan de wand. Aansluitingen voor water en elektriciteit aan de zijkant. Verkrijgbaar bij d...

Horizontal Designer Radiators | Affordable Radiato

Horizontal Designer Radiators | Affordable Radiato

Horizontal radiators have seen huge advancements in design - both in terms of looks, heat output and styling - since they first became widespread in British homes in the middle of the 20th century.Today, far from being bland and boring metal boxes, modern

The Difference Between Vertical Boiler And Horizontal Boil

The Difference Between Vertical Boiler And Horizontal Boil

The gas consumption of the boiler is mainly determined by the boiler efficiency. In terms of cost, the choice of vertical boiler or horizontal boiler is mainly based on the installation site. The small and narrow application of the site can choose vertica

Horizontale elektrische boilers - De Groene Ho

Horizontale elektrische boilers - De Groene Ho

Kenmerken van een horizontale boiler. De Eldom horizontale boilers hebben een 32mm isolatie (CFK-vrij). Deze isolatie is gemaakt van een speciaal schuim dat een hoge dichtheid heeft. Hierdoor zal het water nauwelijks afkoelen en dat werkt kostenbesparend!

difference between vertical boiler and horizont

difference between vertical boiler and horizont

2.How much the price of difference between vertical boiler and horizontal ? We need know the details of Three Pass Fully Wet Back Boiler, for example capacity, pressure, etc, water tube boiler cost, please contact online service. 3.How about the quality o

Biomass Combustion Systems, I

Biomass Combustion Systems, I

Other systems blow the fuel into the boiler and burn most fuel in suspension. Once the fuel particles are in suspension they can carry over into the boiler section, reducing the efficiency of the heat transfer in the boiler, increasing tube cleaning maint

Vertical Boilers - Hurst Boil

Vertical Boilers - Hurst Boil

Vertical Boilers The compact, space saving vertical four-pass shock-proof design has no tubes to loosen or burn out. The Hurst Vertical Tubeless Boiler allows convenient access to "eye high" burner and solid-state controls for trouble free operation.

Gas Fired Steam Boiler,Horizontal Steam Boiler,Gas Fir

Gas Fired Steam Boiler,Horizontal Steam Boiler,Gas Fir

Tips about selecting Steam Boilers model. Unless space of boiler room is limited, horizontal boilers rather than vertical boilers are recommended because horizontal boilers have higher efficiency. In case steam pressure is above 1.6Mpa, water tube boilers

Horizontal condensing gas steam boil

Horizontal condensing gas steam boil

The boiler adopts the design concept of flue gas cascade utilization. The flue gas flow process fully absorbs a large amount of waste heat, which greatly improves the boiler efficiency and can reach 104%.

marine boiler | Horizontal Gas Boilers Manufactur

marine boiler | Horizontal Gas Boilers Manufactur

Global Boiler Group Global Boiler Group Global Boiler is your highly qualified one stop dedicated supplier for service, repairs and spare parts of/for all kinds of boilers/burners, – whether a small donkey boiler on a cargo vessel, a large AUX boiler on a

Horizontal Gas Boilers Manufactur

Horizontal Gas Boilers Manufactur

Sitong horizontal gas fired boiler manufacturer, Sitong is the leader of horizontal gas fired boiler, manufacturing horizontal gas fired steam boiler , horizontal gas fired hot water boiler Horizontal Gas Boilers Manufacturer

Horizonta

Horizonta

Armoire lit horizontale escamotable STRADA V2 blanc mat couchage 140 *. ARMOIRE LIT ULTRA PLATE POUR UN GAIN DE PLACE MAXIMUM Cette armoire lit STRADA V2 se transforme en de...